Vans RV Builders List
Vans Parts Vendors
EAA FAA
Sun n Fun FAA Registry
Oshkosh NTSB
Home Empennage kit Wing Kit Fuselage Kit Finish Kit Power Plant Kit Avionics Paint Interior Home
WING ATTACH WIRING FLIGHT CONTROL  MISCELLANEA CANOPY LANDING GEAR FUEL COWLING OPTION'S  BUILDERS LOG
Page 32.05: FLIGHT CONTROLS
32.01 32.02 32.03 32.04 32.05 32.06 32.07 32.08 32.09 32.10  
32.11 32.12 31.13 32.14              
Step 01: Make two Control Stick Pushrods Assemblies from F-1264 Control Stick Pushrods and the hardware called out in Figure 1.
11/16/13
Bulider Note: See 32.04.04
Step 02: Clamp the Bras Bushings BS .245 X .375 X 2 in a bench vise ( be carful not to over tighten or gouge the bushing ), then drill the inside diameter using a 1/4 drill bit.

Builder Note: The lathe works for this task.

11/16/13
Step 03: Use a file to progressivelty remove material from the ends of both Brass Bushings BS .245 X 2 until they closely fit between the flanges of the brackets of both ends of the WD- 1210 Control column see Figure 2.

Builder Note: Cut square to 2.015"
Builder Note: 2.015"

11/16/13
Step 04: Use a file to progressively remove material from the ends of the tubes in the WD-1212 Control Sticks witch sleeve the Brass Bushing BS .245 X 2. Remove material until, when bolted in place, the brackets on the WD-1210 Control Column clamp on the brass bushings and just clear the tubes See Figure 2.

11/16/13
Step 05: Attach the WD-1212 Control Sticks to the WD-1210 Control Column using the harware called out in Figure 2.

11/16/13		   No Photo  
Step 06: Attach the outboard ends of the contron Stick Assemblies to theWD-1212 Control Sticks as shown in Figure 2. Builder Note: This step was accomplished before Step: 05
See Photo in Step:04, This makes installing the washers and torqueing the bolts easy.
Step 07: Attach the inboard ends of the Control Stick Pushrod Assemblies to the F-1263A & B Flaperon Mixer Bellcranks as shown in Figure 2.

11/16/13		 No Photo
Page 32.05: FLIGHT CONTROLS
32.01 32.02 32.03 32.04 32.05 32.06 32.07 32.08 32.09 32.10  
32.11 32.12 31.13 32.14              
WING ATTACH WIRING FLIGHT CONTROL  MISCELLANEA CANOPY LANDING GEAR FUEL COWLING OPTION'S  BUILDERS LOG
Drill Chart Tap Chart Bolt Chart Nut Chart Rivet Chart Washer Chart Rod Ends Vendors Shop Home

Disclaimer : Information contained on this Site may be out of date and /or inaccurate - Please Confirm any important data with a reliable source.